Chapter 5 - Chemical Storage - doe-hdbk-1139-3-20050047

DOE-HDBK-1139/3-2005

Chapter 5 - Chemical Storage

1.0 Introduction

This chapter identifies and consolidates existing user safety and health requirements found in DOE

and Federal chemical-related safety and health regulations and National Standards that address the

storage of chemicals (see definition) and chemical products (see definition). It specifically

consolidates requirements found in the American National Standards Institute (ANSI) Z49.1, the

Compressed Gas Association (CGA) G-1, and CGA P-1, National Fire Protection Association

(NFPA) 30, NFPA 45, NFPA 51, NFPA 55, NFPA 430, NFPA 432, the Occupational Safety and

Health Administration (OSHA) regulations found at 29CFR1910.6, 29CFR1910.106,

29CFR1910.134, 29CFR1910.253, 29CFR1926.350, and 29CFR1910.1200. It includes requirements

that are cited in either DOE O 440.1A or 29CFR1910.6 ("Incorporation by Reference") and technical

standards that are made mandatory by their specific reference within a regulation, rule or DOE Order.

State and local codes and requirements are NOT included. USDA regulations are NOT addressed

since the impact from these is considered to be negligible at DOE facilities. Similarly, EPA pesticide

regulations are NOT addressed in this document since most DOE sites do not routinely store

pesticides.

This chapter is intended to list chemical-related safety and health requirements and to consolidate

those that are overlapping and/or duplicative. The list of requirements includes "pointers" to the

sources of those requirements.

This document does NOT create any new or additional requirements.

2.0 Applicability

This chapter applies to all locations that store chemicals or chemical products.

[NOTE: Throughout this document, the term "chemicals" is used to indicate chemicals

and/or chemical products as described in Section 3, below.]

This document does NOT apply to:

chemicals stored in tanks with a greater than 735-pound water capacity;

drums that have a greater than 55 gallon capacity;

chemical distribution systems (see definition);

storage containers attached to a system;

waste chemical storage;

the building or design of chemical storage areas [a design engineer who is acquainted with those

requirements should be consulted before a chemical storage facility is built or before an existing

facility is converted to chemical storage.]

Special laboratory requirements presented in this document apply to laboratories that are constructed

and operated in accordance with NFPA 45, "Standard on Fire Protection for Laboratories Using

Chemicals."

This chapter consolidates existing core safety and health requirements that all sites must follow when

engaged in chemical-related activities. The requirements included in this chapter come from sources

that have different safety purposes. As a result, some of these requirements may not always be